Análise comparativa dos efeitos da carga orgânica e do tempo de detenção hidráulica na digestão anaeróbia mesofílica de lodo adensado de estação de tratamento de esgoto

This study compared the performance of a pilot anaerobic sludge digester under different operating strategies. The influence of increasing organic loading rate - OLR (OP I) and the effect of hydraulic retention time - HRT reduction (OP II and OP III) in anaerobic process were evaluated. The applied loads ranged between 0.5 and 4.5 kgSV.m-3.d-1; HRT was reduced from 15 to 5 days. Production of methane, organic matter degradation and microbial diversity were used to measure and compare the system´s performance. Acclimation periods were taken for each new OLR applied, leading to instabilities in sludge VS and COD removals. The experimental time with HRT between 7 and 5 days showed the highest VS efficiency removals (higher than 70%), which positively influenced process stability. The applied OLR of 2.5 and 3.5 kgVS.m-3.d-1 resulted in higher yields of methane during OP I. CH4 production showed impaired with HRT lower than 7 days, although it was observed active methanogenic microorganisms in the digester. Comparatively, HRT reduction resulted in a better system performance than the increasing OLR approach. The lower HRT applied, the better the results obtained in the operation of the digester, suggesting that the process efficiency is optimized with high load operation at low hydraulic retention times.

Mots clés

anaerobic digestion; waste activated sludge; organic loading rate; hydraulic retention time; methanogenic archaeans; methane.